|
If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
Datasheet File OCR Text: |
Bulletin PD-21007 01/05 83CNQ...APbF 83CNQ...ASMPbF SCHOTTKY RECTIFIER New GenIII D-61 Package Major Ratings and Characteristics Characteristics IF(AV) Rectangular waveform VRRM range IFSM @ tp = 5 s sine VF TJ @ 40 Apk, TJ = 125C (per leg) range 80 Amp Description/ Features Units A V A V The center tap Schottky rectifier module series has been optimized for low reverse leakage at high temperature. The proprietary barrier technology allows for reliable operation up to 175 C junction temperature. Typical applications are in switching power supplies, converters, free-wheeling diodes, and reverse battery protection. 175 C TJ operation Center tap module High purity, high temperature epoxy encapsulation for enhanced mechanical strength and moisture resistance Low forward voltage drop High frequency operation Guard ring for enhanced ruggedness and long term reliability Values 80 80, 100 7000 0.67 - 55 to 175 C New fully transfer-mold low profile, small footprint, high current package Through-hole versions are currently available for use in Lead-Free applications ("PbF" suffix) Case Styles 83CNQ...APbF 83CNQ...ASMPbF D61-8 www.irf.com D61-8-SM 1 83CNQ...APbF, 83CNQ...ASMPbF Series Bulletin PD-21007 01/05 Voltage Ratings Part number VR Max. DC Reverse Voltage (V) VRWM Max. Working Peak Reverse Voltage (V) 83CNQ080A.. 80 83CNQ100A.. 100 Absolute Maximum Ratings Parameters IF(AV) Max. Average Forward Current * See Fig. 5 IFSM EAS IAR Max. Peak One Cycle Non-Repetitive Surge Current (Per Leg) * See Fig. 7 Non-Repetitive Avalanche Energy (Per Leg) Repetitive Avalanche Current (Per Leg) 7000 720 15 1 A mJ A 5s Sine or 3s Rect. pulse 10ms Sine or 6ms Rect. pulse Following any rated load condition and with rated VRRM applied 83CNQ Units 80 A Conditions 50% duty cycle @ TC = 132 C, rectangular wave form TJ = 25 C, IAS = 1 Amps, L = 30 mH Current decaying linearly to zero in 1 sec Frequency limited by TJ max. VA = 1.5 x VR typical Electrical Specifications Parameters VFM Max. Forward Voltage Drop (Per Leg) * See Fig. 1 (1) 83CNQ Units 0.81 1.00 0.67 0.82 1.5 35 1400 5.5 10000 V V V V mA mA pF nH V/ s @ 40A @ 80A @ 40A @ 80A TJ = 25 C Conditions TJ = 25 C TJ = 125 C VR = rated VR IRM CT LS Max. Reverse Leakage Current (Per Leg) * See Fig. 2 (1) Max. Junction Capacitance (Per Leg) Typical Series Inductance (Per Leg) TJ = 125 C VR = 5VDC, (test signal range 100Khz to 1Mhz) 25C Measured lead to lead 5mm from package body dv/dt Max. Voltage Rate of Change (Rated VR) (1) Pulse Width < 300s, Duty Cycle <2% Thermal-Mechanical Specifications Parameters TJ Tstg Max. Junction Temperature Range Max. Storage Temperature Range 83CNQ Units -55 to 175 -55 to 175 0.85 0.42 0.30 C C Conditions RthJC Max. Thermal Resistance Junction to Case (Per Leg) RthJC Max. Thermal Resistance Junction to Case (Per Package) RthCS Typical Thermal Resistance, Case to Heatsink (D61-8 Only) wt T Approximate Weight Mounting Torque (D61-8 Only) Min. Max. C/W DC operation C/W DC operation * See Fig. 4 C/W Mounting surface , smooth and greased Device flatness < 5 mils Kg-cm (*) (Ibf-in) 7.8 (0.28) g (oz.) 12 (10) 24 (20) (*) Recommended hardware 3M stainless screw 2 www.irf.com 83CNQ...APbF, 83CNQ...ASMPbF Series Bulletin PD-21007 01/05 1000 Reverse Current - I R (mA) 1000 100 10 1 0.1 0.01 0.001 0 20 40 60 80 100 T = 175C J 150C 125C 100C 75C 50C 25C 100 Instantaneous Forward Current - I F (A) 10 T J = 175C Junction Capacitance - C T (p F) Reverse Voltage - VR (V) Fig. 2 - Typical Values Of Reverse Current Vs. Reverse Voltage (Per Leg) 10000 T J = 125C T = 25C J T = 25C J 1 1000 0.1 0 0.2 0.4 0.6 0.8 1 1.2 1.4 Forward Voltage Drop - VFM (V) Fig. 1 - Max. Forward Voltage Drop Characteristics (Per Leg) 100 0 20 40 60 80 100 120 Reverse Voltage - VR (V) Fig. 3 - Typical Junction Capacitance Vs. Reverse Voltage (Per Leg) 1 (C/W) D = 0.50 D = 0.33 D = 0.25 D = 0.17 PDM Thermal Impedance Z thJC 0.1 D = 0.08 t1 t2 Notes: Single Pulse (Thermal Resistance) 1. Duty factor D = t1 / t2 2. Peak Tj = Pdm x ZthJC + Tc 0.01 0.00001 0.0001 0.001 0.01 0.1 1 t 1 , Rectangular Pulse Duration (Seconds) 10 100 Fig. 4 - Max. Thermal Impedance ZthJC Characteristics (Per Leg) www.irf.com 3 83CNQ...APbF, 83CNQ...ASMPbF Series Bulletin PD-21007 01/05 180 Allowable Case Temperature (C) 40 RthJC (DC) = 0.85 C/W Average Power Loss (Watts) 35 30 25 20 170 D = 0.08 D = 0.17 D = 0.25 D = 0.33 D = 0.50 DC RMS Limit 160 DC 15 10 5 0 0 10 20 30 40 50 60 150 140 0 10 20 30 40 50 60 Average Forward Current - I F(AV) (A) Fig. 5 - Max. Allowable Case Temperature Vs. Average Forward Current (Per Leg) Non-Repetitive Surge Current - I FSM (A) Average Forward Current - IF(AV) (A) Fig. 6 - Forward Power Loss Characteristics (Per Leg) 10000 1000 At Any Rated Load Condition And With Rated Vrrm Applied Following Surge 100 10 100 1000 10000 Square Wave Pulse Duration - tp (microsec) Fig. 7 - Max. Non-Repetitive Surge Current (Per Leg) L HIGH-SPEED SWITCH FREE-WHEEL DIODE 40HFL40S02 Vd = 25 Volt DUT IRFP460 Rg = 25 ohm + CURRENT MONITOR Fig. 8 - Unclamped Inductive Test Circuit 4 www.irf.com 83CNQ...APbF, 83CNQ...ASMPbF Series Bulletin PD-21007 01/05 Outline Table Outline D61-8 Dimensions are in millimeters and (inches) Outline D61-8-SM Dimensions are in millimeters and (inches) www.irf.com 5 83CNQ...APbF, 83CNQ...ASMPbF Series Bulletin PD-21007 01/05 Marking Information Outline D61-8 INTERNATIONAL RECTIFIER LOGO THIS IS A 83CNQ100 WITH LOT CODE 89 09 ASSEMBLED ON WW 45, 2000 PART NUMBER 83CNQ100A 89 09 045P DATE CODE ASSEMBLY LOT CODE YEAR 0 = 2000 WEEK 45 P = LEAD-FREE Outline D61-8-SM INTERNATIONAL RECTIFIER LOGO THIS IS A 83CNQ100ASM WITH LOT CODE 89 09 ASSEMBLED ON WW 45, 2000 PART NUMBER 83CNQ100ASM 89 09 045P DATE CODE YEAR 0 = 2000 WEEK 45 P = LEAD-FREE ASSEMBLY LOT CODE 6 www.irf.com 83CNQ...APbF, 83CNQ...ASMPbF Series Bulletin PD-21007 01/05 83CNQ100A ******************************************** * This model has been developed by * * Wizard SPICE MODEL GENERATOR (1999) * * (International Rectifier Corporation) * * contains Proprietary Information * ******************************************** * SPICE Model Diode is composed by a * * simple diode plus paralled VCG2T * ******************************************** .SUBCKT 83CNQ100A ANO CAT D1 ANO 1 DMOD (0.20831) *Define diode model .MODEL DMOD D(IS=3.91765102575707E-04A,N=1.6412007115037,BV=110V, + IBV=1.66611874283115A,RS= 0.001083212,CJO=1.31909764291715E-08, + VJ=1.04145964983498,XTI=2, EG=0.757359996913038) ******************************************** *Implementation of VCG2T VX 1 2 DC 0V R1 2 CAT TRES 1E-6 .MODEL TRES RES(R=1,TC1=-5.06642501757023) GP1 ANO CAT VALUE={-ABS(I(VX))*(EXP((((2.558893E-02/-5.066425)*((V(2,CAT)*1E6)/(I(VX)+1E-6)1))+1)*3.120336E-03*ABS(V(ANO,CAT)))-1)} ******************************************** .ENDS 83CNQ100A Thermal Model Subcircuit .SUBCKT 83CNQ100A 5 1 CTHERM1 CTHERM2 CTHERM3 CTHERM4 RTHERM1 RTHERM2 RTHERM1 RTHERM1 5 4 3 2 5 4 3 2 4 3 2 1 4 3 2 1 8.75E-04 1.99E+00 2.04E+01 2.41E+02 1.00E-07 4.51E-01 3.08E-01 7.27E-02 .ENDS 83CNQ100A www.irf.com 7 83CNQ...APbF, 83CNQ...ASMPbF Series Bulletin PD-21007 01/05 Ordering Information Table Device Code 83 1 C 2 N 3 Q 4 100 5 A 6 PbF 7 1 2 3 4 5 6 7 - Current Rating (80A) Circuit Configuration C = Common Cathode Package N = D-61 Schottky "Q" Series Voltage Ratings A = D-61-8 package style ASM = D-61-8-SM package style none = Standard Production PbF = Lead-Free Standard pack quantity: A = 10 pieces 080 = 80V 100 = 100V ASM = 20 pieces Data and specifications subject to change without notice. This product has been designed and qualified for Industrial Level and Lead-Free. Qualification Standards can be found on IR's Web site. IR WORLD HEADQUARTERS: 233 Kansas St., El Segundo, California 90245, USA Tel: (310) 252-7105 TAC Fax: (310) 252-7309 Visit us at www.irf.com for sales contact information. 01/05 8 www.irf.com |
Price & Availability of 83CNQ100ASMPBF |
|
|
All Rights Reserved © IC-ON-LINE 2003 - 2022 |
[Add Bookmark] [Contact Us] [Link exchange] [Privacy policy] |
Mirror Sites : [www.datasheet.hk]
[www.maxim4u.com] [www.ic-on-line.cn]
[www.ic-on-line.com] [www.ic-on-line.net]
[www.alldatasheet.com.cn]
[www.gdcy.com]
[www.gdcy.net] |